Front tire blowout at 75mph....

Discussion in 'General Harley Davidson Topic' started by 89stroker, Jun 30, 2012.

  1. 89stroker

    89stroker Active Member

    186
    0
    2
    Actually wasn't as bad as one thinks as I was on a straight piece of road. Scared my buddy who was just behind worse than it scared me. The tire went off like a shotgun blast on my '99 FXST, instantly flat, no problem until I let off the throttle, then the front end felt a little funny. Coasted to a stop without touching brakes or making any sudden manuevers. Glad I wasn't in a high speed sweeper at the time....Last time I had a blowout like this it was on a back tire and it landed me in a ditch.
    Haven't had time yet to diagnose what happened yet only that I have pulled the front wheel and have found no punctures or marks on the tire, so just the tube blew out. I put a new rim strip, tube and tire on 2000 miles ago so I don't think it would be a pinched tube. Only thing I can think of is the tire went low and heated everything up and Kapow! I tested air pressure just before I left to meet my buddy, pressure was at 36 psi. Normally I make sure after testing the stem is not leaking but I did not so that this time as I was late to meet my buddy for breakfast 110 miles away. I was late so I sustained 80-90 mph speeds to make up time. Met him, had breakfast then this happened about 50 miles after.

    Any theories out there?
     
  2. oldhippie

    oldhippie Senior Member

    1,072
    58
    19
    Glad you made it alright.:bigsmiley12:
     
  3. 89stroker

    89stroker Active Member

    186
    0
    2
    Thanks Fellas.

    OldHippie, I am going for a rip on your side of the fence today, probably make a run up through Riding Mountain, Duck Mountain up to Swan River then back over to my side of the fence. Some time we should plan a little meet and greet.
     
  4. gusotto

    gusotto Junior Member

    597
    38
    11
    Check the inside of the tube.
    A spoke flat will show up there.
    Then you can match it to the guilty spoke, if it is a spoke flat.
     
  5. 89stroker

    89stroker Active Member

    186
    0
    2
    Thanks, will do.

    All spokes seem tight, but once I get tire and tube off, something may rear its head.
     
  6. Webbtron

    Webbtron Banned

    583
    0
    1
    Do you think someone messed with it in the parking lot?
     
  7. fin_676

    fin_676 Experienced Member Staff Member Moderator Contributor

    5,275
    133
    156
    Glad to hear that you are ok and am waiting to hear what you find when you get the tyre off
    I have had a blowout or two in the past and the front was a lot easier to control than the back although they were on different bikes
    In the past the steel bands in the tyre could snap and puncture the tube and on inspection you would not find the reason for the hole in the tube but once under pressure the tube would puncture again
    I do think it has been a long time since steel bands have been used in tyres

    Brian
     
  8. Hoople

    Hoople Account Removed

    7,198
    0
    34
    "the last time I had a blowout" ? How many times are you going to push "Lady Luck". I would be getting some cast wheels or late model laced tubeless wheels. At least change brands of rubber your using. I mean, somethings not right.
     
  9. garystrat

    garystrat Banned

    52
    0
    0
    from what you've said my instincts say the bead was not seated which when it did would explain the "shotgun" sound and the loss of air pressure. 2nd guess would be the valve stem rocketed but that would be more likely on a tubeless type rim...
     
  10. 89stroker

    89stroker Active Member

    186
    0
    2
    I doubt it.

    Quite a number of years ago was the last time and it was on a cast rim on a different bike.

    I had rode the bike with this tire for over 200 miles before this happened. Valve stem is still there.
     
    Last edited by a moderator: Jun 30, 2012